はじめに

The iPhone 6 launched last week - and is already out of stock! In preparation to the iPhone 6 teardown, we went ahead with the teardown by x-ray of the Apple iPhone 5S.

Before we begin, let's take a look at the 5s specs.

  • Apple A7 processor with 64-bit architecture.
  • M7 motion co-processor.
  • 16, 32, or 64 GB Storage.
  • 4-inch retina display with 326 ppi.
  • 8 MP iSight camera (with larger 1.5µ pixels) and a 1.2MP FaceTime camera.
  • Fingerprint identity sensor built into the home button.
  • Available in three different colors: space gray, silver, and gold.

The iPhone 5S we x-ray inspected is a white device with 16GB of memory. The x-ray inspection was done without removing any parts of the phone - we didn't even power it off!

Looks good on the outside, now let's take a look inside.

この分解は修理ガイドでは ありません。 お持ちのiPhone 5Sを修理する際は、iFixitの修理ガイドをご利用ください。

We are going to take a look inside an iPhone 5s using a high resolution x-ray inspection system - the TruView 200. This system packs an impressive 130kV microfocus source and a large 3"x4" x-ray sensor capable of delivering 1um resolution.
  • We are going to take a look inside an iPhone 5s using a high resolution x-ray inspection system - the TruView 200. This system packs an impressive 130kV microfocus source and a large 3"x4" x-ray sensor capable of delivering 1um resolution.

  • For more information about the system we used please visit TruView Number Series.

コメントを追加する

Now it's time to start the x-ray inspection!
  • Now it's time to start the x-ray inspection!

  • 1.2MP FaceTime camera.

  • 8 MP iSight camera (with larger 1.5µ pixels).

  • Yellow: Apple A7 processor with 64-bit architecture

  • This iPhone 5S has a 3.8V - 5.92Wh - 1560 mAh battery. Not much improvement from the iPhone 5 3.8 V - 1440 mAh - 5.45 Wh. Talk time: Up to 8 hours on 3G. Standby time: Up to 225 hours.

  • Speaker

  • Lightning connector and Touch ID interface

  • 3.5mm audio jack

コメントを追加する

Here's some of the powertrain in the iPhone 5S:
  • Here's some of the powertrain in the iPhone 5S:

  • Apple 338S120L.

  • Qualcomm PM8018 RF power management IC and Qualcomm MDM9615M LTE Modem

  • Qualcomm WTR1605L LTE/HSPA+/CDMA2K/TDSCDMA/EDGE/GPS transceiver.

  • Avago A790720

コメントを追加する

We know voids in ball grid arrays (BGA) can be problematic to the reliability of any electronic product. In our x-ray inspection of the iPhone 5S, we noticed that the Apple 338S120L chipset had a large number of voids. So the natural next step was to use the BGA inspector included in the TruView 200 to measure the voids.
  • We know voids in ball grid arrays (BGA) can be problematic to the reliability of any electronic product. In our x-ray inspection of the iPhone 5S, we noticed that the Apple 338S120L chipset had a large number of voids. So the natural next step was to use the BGA inspector included in the TruView 200 to measure the voids.

コメントを追加する

A quick analysis of the BGA voiding in the Apple 338S120L shows voids as large as 35%. That does not mean this is a problem, but certainly something a quality manager would need to check and validate. Besides, none of the other surface mount components in the iPhone 5S have this level of voiding. The BGA inspector allows us to visualize the void in a 3D representation of x-y and density as the height of the volume.
  • A quick analysis of the BGA voiding in the Apple 338S120L shows voids as large as 35%. That does not mean this is a problem, but certainly something a quality manager would need to check and validate. Besides, none of the other surface mount components in the iPhone 5S have this level of voiding.

  • The BGA inspector allows us to visualize the void in a 3D representation of x-y and density as the height of the volume.

コメントを追加する

Closer look... the iPhone 5s iSight Camera has 8 megapixels of fun, autofocus and auto HDR for photos, among other features.
  • Closer look... the iPhone 5s iSight Camera has 8 megapixels of fun, autofocus and auto HDR for photos, among other features.

  • Size wise its not much different than the Camera on the iPhone 5.

コメントを追加する

This corner shot of the iPhone 5S shows the standard 3.5mm audio jack. You can also see the corner of the Touch ID interface and supporting mechanics.
  • This corner shot of the iPhone 5S shows the standard 3.5mm audio jack. You can also see the corner of the Touch ID interface and supporting mechanics.

コメントを追加する

Here's a detail image of the Touch ID sensor. Note that it sits on top of the Lightning connector, that's why you see them overlaid in this x-ray image. Here's a detail image of the Touch ID sensor. Note that it sits on top of the Lightning connector, that's why you see them overlaid in this x-ray image.
  • Here's a detail image of the Touch ID sensor. Note that it sits on top of the Lightning connector, that's why you see them overlaid in this x-ray image.

コメントを追加する

This corner of the iPhone 5S has not changed since the iPhone 5/4S. The large high performance speaker is located in the same place, and the antennae connections are very similar to previous models.
  • This corner of the iPhone 5S has not changed since the iPhone 5/4S. The large high performance speaker is located in the same place, and the antennae connections are very similar to previous models.

Nooo lo entiendooo alguien q hable español me lo esplica por favor

tania karoline giraldo manco - 返信

Christina Hall

メンバー登録日: 2014年09月18日

1,018 ポイント

2のガイドは作成済み

チーム

X-ray Inspectors X-ray Inspectors人のメンバー

Community

1 メンバー

2のガイドは作成済み

Jajajaja que es lo que no entiendes para poder ayudarte?

Nelson - 返信

Como ago funcionar mi 5s

Ezequiel Pineda - 返信

コメントを追加する

統計データを表示:

過去 24時間: 1

過去 7 日: 26

過去 30 日: 135

今までの合計 20,035