HP Pavilion ze5000 Primary Fan Replacement

はじめに

This guide will explain how to replace the primary fans of the device. There is another fan located in the northern section of the interior of the device that this repair guide will not cover. This guide deals with the more involved sections of the device.

必要な工具と部品

手順1 Battery

HP Pavilion ze5000 Primary Fan Replacement, Battery: 手順 1、 1の画像 1

Push up on the arrow-shaped switch.

編集

手順2

While still holding the switch up, remove the battery.

編集

手順3 Keyboard

HP Pavilion ze5000 Primary Fan Replacement, Keyboard: 手順 3、 3の画像 1

HP Pavilion ze5000 Primary Fan Replacement, Keyboard: 手順 3、 3の画像 2

HP Pavilion ze5000 Primary Fan Replacement, Keyboard: 手順 3、 3の画像 3

Remove the two 5mm Phillips #0 screws from the hinges

編集

手順4

Open the device as if you were going to use the device. Using Tweezers, pry the hinges from underneath the screen
Not much force is needed to pull the hinges off once the tweezers are properly positioned

編集

手順5

Remove the wire connection by gently pulling on the fuse and connection itself.
Do not pull on the wires, as this can remove the wires from the connection, destroying the fuse.

編集

手順6

HP Pavilion ze5000 Primary Fan Replacement: 手順 6、 3の画像 3

Remove the four 4.0 mm Phillips #0 connecting the keyboard to the frame

編集

手順7

Gently lift the keyboard up from the frame so that you can see the ribbon still connected.

編集

手順8

HP Pavilion ze5000 Primary Fan Replacement: 手順 8、 3の画像 3

Remove the ribbon by gently pulling up the ends of the white receiver it is inserted in to.
You may need to use tweezers for this part.
During reassembly, when inserting the ribbon, you will hear a quiet, clicking sound when pushing down on the ends of the receiver. Hearing this ensures the ribbon is in place.

編集

手順9 Primary Fan

HP Pavilion ze5000 Primary Fan Replacement, Primary Fan: 手順 9、 1の画像 1

Remove sixteen 5.0 mm Phillips #1 screws from the underside of the device

編集

手順10

Remove the one 5.0 mm Phillips #1 screw underneath the battery home

編集

手順11

HP Pavilion ze5000 Primary Fan Replacement: 手順 11、 3の画像 3

Remove the additional four 5.0 mm Phillips #1 screws from the hinge of the device

編集

手順12

Remove the two 4.0 mm Phillips #0 screws attached to the cicuit board above the keyboard

編集

手順13

Gently remove the disconnection to the right of the circuit board

編集

手順14

Take the circuit board off by pulling up on the right side of the circuit board
The board is plugged in to the device at this location still, but the outlet is hidden.
Pulling on the right side can snap the circuit board, so it is essential you pull on this side only

編集

手順15

Remove the five 5.0 mm Phillips #1 screws from underneath the keyboard

編集

手順16

HP Pavilion ze5000 Primary Fan Replacement: 手順 16、 3の画像 3

Disconnect the ribbons from the circuit board underneath the keyboard housing unit

編集

手順17

HP Pavilion ze5000 Primary Fan Replacement: 手順 17、 3の画像 3

Remove the connection beneath the left hinge of the device

編集

手順18

Pry the device apart to expose the inside of the device
This should be relatively easy since all connections and screws are removed. However, a spudger can be used if you are having difficulties.

編集

手順19

HP Pavilion ze5000 Primary Fan Replacement: 手順 19、 3の画像 3

Remove the latches securing the fan housing unit by unscrewing the six 4.0 mm Phillips #0 screws

編集

手順20

Lift the housing unit a few inches from the device to expose the two small connections.

編集

手順21

Remove the two small connections directly above and below the fan housing unit

編集

手順22

Remove the fan housing unit and flip it over

編集

手順23

HP Pavilion ze5000 Primary Fan Replacement: 手順 23、 3の画像 3

Remove the eight 3.5 mm Phillips #00 screws from the fan housing unit

編集

手順24

Remove both or whichever fan needs to be replaced
There should be bronze electric tape on the fan housing unit. Do not hesitate to tear the tape in order to open the housing unit

編集